Moisture effect on the dielectric response of improved insulating papers impregnated with mineral oil
I. Antolin(1), D. García(2), C. Olmo(1), F. Delgado(1) and J. Torregrosa(3) 1. Department de Ingeniería Eléctrica y Energética, E.T.S.I.I.T., Universidad de Cantabria, Santander (Spain) 2. High Voltage Research Group, School of Electrical and Electronic Engineering, Universidad del Valle, Campus Meléndez, Cali (Colombia) 3.TMG Solutions, Viladecavalls, Barcelona (Spain) 2026-01-20

Abstract

The electrical insulation system, usually composedof cellulosic materials and mineral oil, is essential for the reliable operation of the power transformers. The dielectric system must be kept in prime condition to increase the lifetime of the machine. Moisture in these materials reduces the dielectric strength and enhances the rate of insulation ageing. Frequency Domain Spectroscopy (FDS) is a promising method to analyse the effect of moisture in oil-paper insulation system. This study compares the influence of moisture on the dielectric capacity of 3 insulating papers; Diamond Printed Enhanced (DPE), Kraft and Thermally Upgraded Kraft (TUK) impregnated with mineral oil using FDS. The samples were prepared in the laboratory with different moisture content within 1% to 5%. Measurements were performed over a wide frequency range from 16.62 mHz to 5 kHz. It was found that the dielectric magnitudes measured on the DPE paper samples are higher compared to the other two types of paper samples and that the dielectric response is adversely affected by moisture content, regardless of the type of paper.

Key words: Dielectric response, FDS, insulating papers, mineral oil, moisture.

References

[1] I. Power and E. Society, IEC/IEEE 60076-16-2018, Power transformers – Part 16: Transformers for wind turbine applications. 2018. [Online]. Available: www.iec.ch

[2] J. Hao et al., “Synergistic enhancement effect of moisture and aging on frequency dielectric response of oil-immersed cellulose insulation and its degree of polymerization evaluation using dielectric modulus,” Cellulose, vol. 28, no. 1. Springer Science and Business Media B.V., Jan. 01, 2021. doi: 10.1007/s10570-020-03524-9.

[3] Q. Xu, S. Wang, F. Lin, and H. Li, “Moisture Assessment of Oil-Immersed Paper Based on Dynamic Characteristics of Frequency Domain Spectroscopy,” IEEE Access, vol. 10, pp. 15183–15192, 2022, doi: 10.1109/ACCESS.2022.3147463.

[4] R. Jadav, C. Ekanayake, and T. Saha, “Understanding the impact of moisture and ageing of transformer insulation on frequency domain spectroscopy,” IEEE Transactions on Dielectrics and Electrical Insulation, vol. 21, no. 1, pp. 369–379, 2014, doi: 10.1109/TDEI.2013.003984.

[5] K. Bandara, C. Ekanayake, and T. K. Saha, “Analysis of Frequency Domain Dielectric Response of Pressboard Insulation Impregnated with Different Insulating Liquids,” IEEE Transactions on Dielectrics and Electrical Insulation, vol. 23, 2016, doi: 10.1109/TDEI.2016.005634.

[6] J. Liu, X. Fan, Y. Zhang, C. Zhang, and Z. Wang, “Aging evaluation and moisture prediction of oil-immersed cellulose insulation in field transformer using frequency domain spectroscopy and aging kinetics model,” Cellulose, vol. 27, no. 12, pp. 7175–7189, Aug. 2020, doi: 10.1007/s10570-020-03242-2.

[7] B. García, D. García, and G. Robles, “Development of a Moisture-In-Solid-Insulation sensor for power transformers,” Sensors (Switzerland), vol. 15, no. 2, pp. 3610–3624, Feb. 2015, doi: 10.3390/s150203610.

[8] L. S. Cao et al., “Moisture and thermal aging effects on the FDS measurement of silicone oil-paper insulation,” in CMD 2016 - International Conference on Condition Monitoring and Diagnosis, Institute of Electrical and Electronics Engineers Inc., Nov. 2016, pp. 400–403. doi: 10.1109/CMD.2016.7757844.

[9] M. R. Patra and B. N. Rao, “A study on the effect of moisture on paper insulation impregnated with mineral oil and ester oil using frequency domain dielectric spectroscopy,” in The 20th International Symposium on High Voltage Engineering, Aug. 2017.

[10] A. Tome Mandala, Z. Tao, J. Shiejie, and Z. Ning, “Analysis of Dielectric Response Measurements for Condition Assessment of Oil-Paper in Power Transformer Insulation,” International Journal of Scientific and Research Publications (IJSRP), vol. 11, no. 5, pp. 145–151, Apr. 2021, doi: 10.29322/ijsrp.11.05.2021.p11318.

[11] WEIDMANN, “WEIDMANN Electrical Insulating Papers.” [Online]. Available: https://www.electro-wind.com/web-files/Weidmann/Literature/electrical-insulating-paper-catalogue.pdf

[12] WEIDMANN, “DPE Technical data sheet” [Online]. Available: https://weidmann-electrical.com/wp-content/uploads/DP-metric-12-20.pdf

[13] OMICRON LAB, “SPECTANO 100 User Manual,” 2018 [Online]. Available: https://www.omicron-lab.com/products/material-analysis/spectano-100

[14] C. Olmo, C. Méndez, P. J. Quintanilla, F. Ortiz, C. J. Renedo, and A. Ortiz, “Mineral and Ester Nanofluids as Dielectric Cooling Liquid for Power Transformers,” Nanomaterials, vol. 12, no. 15. MDPI, Aug. 01, 2022. doi: 10.3390/nano12152723.

[15] C. Méndez Gutiérrez, C. Olmo Salmas, C. J. Renedo Estébanez, M. Kozako, M. Hikita, and A. Ortiz Fernández, “Study of the Thermal Degradation of Different Insulating Papers Impregnated with a Natural Ester,” in 2022 9th International Conference on Condition Monitoring and Diagnosis, CMD 2022, Institute of Electrical and Electronics Engineers Inc., 2022, pp. 167–171. doi: 10.23919/CMD54214.2022.9991628.